Water Heater Pilot Tube Leaking

Disconnect the bracket holding both tubes to the gas valve using a.

Water heater pilot tube leaking.

If there is insulation around the supply tubes remove it so you can inspect and replace the tubes if necessary. If this is a gate style valve a wheel that turns turn the valve clockwise as far as you can. What to do with a leaking water heater step 1. If you experience a leaking water heater it is recommended to turn off the water to your tank.

Locate the pilot tube. You can use a mixture of water and dish soap to discover where it is leaking. To reattach the three lines to the gas valve thread the nuts into place with your fingers and hand tighten them. Water is leaking from my hot water heater in the attic into the bathroom below.

The metals are soft so don t over tighten. It acts as a safety device to prevent gas leaks. Flexible water supply tubes are the most common cause of leaks above the water heater since it is common for these tubes to fail long before the water heater is ready for replacement. Therefore a dirty thermocouple might be the reason why your water pilot keeps going out.

I m not sure of the ratio but you want it the consistency to be somewhat thicker than water maybe 1 cup water and one table spoon dish soap. Although these are the two most common causes of a leaking water heater they are not always the culprits. If the leak is coming from the bottom of the tank it is not looking good for you. The thermocouple is triggered by an electric current produced by the pilot light.

Then snug them up with a quarter to half revolution with a wrench. At first before i knew the name of the pilot tube i figured it was to feed water to the temperature control system to regulate water temperature. As best as i can tell the water is leaking through the pilot tube. The other is the thermocouple tube.

It is one of two small tubes connected to the automatic gas valve. Turn off the water. Combine in a container and gently swish around until it is evenly distributed. The most likely scenario in this case is that sediment has built up and corroded the bottom of the tank causing a serious problem and the need for an entirely new water heater.

Below is a list of the four most probable causes of a leak in your water heater. When relit the water heater pilot light flame should wrap around the thermocouple bulb. How to light a gas water heater pilot light duration.